R900411314 Z2DB6VD2-42/200V力士樂減壓閥

R900411314 Z2DB6VD2-42/200V力士樂減壓閥

減壓閥的作用原理是靠閥內流道對水流的局部阻力降低水壓，水壓降的范圍由連接閥瓣的薄膜或活塞兩側的進出口水壓差自動調節。定比減壓原理是利用閥體中浮動活塞的水壓比控制，進出口端減壓比與進出口側活塞面積比成反比。這種減壓閥工作平穩無振動；閥體內無彈簧，故無彈簧銹蝕、金屬疲勞失效之慮；密封性能良好不滲漏，因而既減動壓（水流動時）又減靜壓（流量為0時）；特別是在減壓的同時不影響水流量。

水流通過減壓閥雖有很大的水頭損失，但由于減少了水的浪費并使系統流量分布合理、改善了系統布局與工況，因此總體上講仍是節能的。介質為蒸汽的場合，宜選用先導活塞式減壓閥或先導波紋管式減壓閥。為了操作、調整和維修的方便，減壓閥一般應安裝在水平管道上。

（1）出口壓力幾乎等于進口壓力，不減壓

這一故障現象表現為：減壓閥進出口壓力接近相等，而且出口壓力不隨調壓手柄的旋轉調節而變化。產生原因和排除方法如下。

①因主閥芯上或閥體孔沉割槽棱邊上有毛刺或者主閥芯與閥體孔之間的間隙里卡有污物，或者因主閥芯或閥孔形位公差超差，產生液壓卡緊，將主閥芯卡死在較大開度(max)的位置上，由于開口大，油液不減壓。此時可根據上述情況分別采取去毛刺、清洗和修復閥孔和閥芯精度的方法予以排除。

②因主閥芯與閥孔配合過緊，或裝配時拉毛閥孔或閥芯，將閥芯卡死在較大開度位置上，此時可選配合理的間隙。J型減壓閥配合間隙一般為0. 007～0. 015mm，配前可適當研磨閥孔，再配閥芯。

③主閥芯短阻尼孔或閥座孔堵塞，失去了自動調節機能，主閥彈簧力將主閥推往較大開度，變成直通無阻，進口壓力等于出口壓力�？捎�φ1. Omm鋼絲或用壓縮空氣吹通阻尼孔，并進行清洗再裝配。

④對J型減壓閥，帶阻尼孔的阻尼件是壓入主閥芯內的，使用中有可能因過盈量不夠而沖出。沖出后，使進油腔與出油腔壓力相等（無阻尼），而閥芯上下受力面積相等，但出油腔有一彈簧，所以主閥芯總是處于較大開度的位置，使出口壓力等于入口壓力。此時需重新加工外徑稍大的阻尼件并重新壓入主閥芯。

⑤JF型減壓閥，出廠時泄油孑L是用油塞堵住的。當此油塞未擰出而使用時，使主閥芯上腔（彈簧腔）困油，導致主閥芯處于較大開度而不減壓。J型管式閥與此相同。J型板式閥如果設計安裝板時未使L口連通油池也會出現此現象。

⑥對J型管式閥，拆修時很容易將閥蓋裝錯方向（錯90°或180°），使外泄油口堵死，無法排油，造成同上的困油現象，使主閥頂在較大開度而不減壓。修理時將閥蓋裝配方向裝對即可。

⑦對JF型減壓閥，頂蓋方向裝錯時，會使輸出油孔與泄油孔相通，造成不減壓，也須注意。

(2)出口壓力很低，即使擰緊調壓手輪，壓力也升不起來

①減壓閥進出油口接反了：對板式閥為安裝板設計有錯，對管式閥是接管錯誤。J型減壓閥的進出油口跟Y型溢流閥的進出油口剛好相反。用戶使用時請注意閥上油口附近所打的鋼印標記（Pl、P2、L等字樣），或查閱液壓元件產品目錄，不可設計錯和接錯。

②進油口壓力太低，經減壓閥芯節流口后，從出油口輸出的壓力更低，此時應查明進油口壓力低的原因（例如溢流閥故障）。

③減壓閥下游回路負載太小．壓力建立不起來，此時可考慮在減壓閥下游串接節流閥來解決。

④先導閥（錐閥）與閥座配合面之間因污物滯留而接觸不良，不密合；或先導錐閥有嚴重劃傷，閥座配合孑L失圓，有缺口，造成先導閥芯與閥座孔不密合。

⑤拆修時，漏裝錐閥或錐閥未安裝在閥座孔內。對此，可檢查錐閥的裝配情況或密合情況。

R900422422 Z2DB6VD2-4X/200

R900562580 Z2DB6VD2-4X/200SO7

R901278991 Z2DB6VD2-4X/200-105

R901092935 Z2DB6VD2-4X/200-120

R900575577 Z2DB6VD2-4X/200-120V

R901041139 Z2DB6VD2-4X/200-140

R900929696 Z2DB6VD2-4X/200-140V

R901041138 Z2DB6VD2-4X/200-50

R901086805 Z2DB6VD2-4X/200-70

R901032861 Z2DB6VD2-4X/200-90

R900505561 Z2DB6VD2-4X/200JV

R901195039 Z2DB6VD2-4X/200MIL15

R901394945 Z2DB6VD2-4X/200P120V

R901321528 Z2DB6VD2-4X/200P160

R900411314 Z2DB6VD2-4X/200V

R900422066 Z2DB6VD2-4X/315

R900559721 Z2DB6VD2-4X/315-100V

R901415337 Z2DB6VD2-4X/315-120V

R900917630 Z2DB6VD2-4X/315-220V

R901295107 Z2DB6VD2-4X/315-240V

R901152443 Z2DB6VD2-4X/315-250V

R900911457 Z2DB6VD2-4X/315-300

R900425914 Z2DB6VD2-4X/315JV

R900521836 Z2DB6VD2-4X/315MIL15

R901367096 Z2DB6VD2-4X/315P110

R900411357 Z2DB6VD2-4X/315V

R900567619 Z2DB6VD2-4X/315VSO7

R900715031 Z2DB6VD2-4X/315V=LH

R901052215 Z2DB6VD2-4X/315V=TE

R900463267 Z2DB6VD2-4X/50

R900421937 Z2DB6VD2-4X/50V

R900442328 Z2DB6VD3-4X/100

R900500691 Z2DB6VD3-4X/100V

R900438962 Z2DB6VD3-4X/200

R900437449 Z2DB6VD3-4X/200V

R900599175 Z2DB6VD3-4X/315V

R900422212 Z2DB6VD3-4X/50

R900500657 Z2DB6VD3-4X/50V

R900743351 Z2DB6VD7-4X/100V

R901080471 Z2DB6VD7-4X/200V

R988004610 Z2DB6VP2-4X/100

R987009792 ZDB6VA3-4X/200SO130

R900476960 ZDB6VA.-4X/...V

R900527144 ZDB6VA1-4X/100

R900507526 ZDB6VA1-4X/100V

R900426313 ZDB6VA1-4X/200

R900433646 ZDB6VA1-4X/200V

R900509893 ZDB6VA1-4X/315

R900522027 ZDB6VA1-4X/315V

R901143640 ZDB6VA1-4X/315XCV

R900967505 ZDB6VA1-4X/50

R900583801 ZDB6VA1-4X/50V

R900437441 ZDB6VA2-4X/100

R900512492 ZDB6VA2-4X/100MIL15

R900437334 ZDB6VA2-4X/100SO2

R901143926 ZDB6VA2-4X/100-100MIL15

R900786652 ZDB6VA2-4X/100-25

R901234984 ZDB6VA2-4X/100-85V

R901437457 ZDB6VA2-4X/100-90

R901395507 ZDB6VA2-4X/100JV

R900409889 ZDB6VA2-4X/100V

R900426329 ZDB6VA2-4X/200

R900969829 ZDB6VA2-4X/200MIL15

R900934816 ZDB6VA2-4X/200-160V

R901043293 ZDB6VA2-4X/200-165

R900978249 ZDB6VA2-4X/200-175

R901050682 ZDB6VA2-4X/200-30

R900520760 ZDB6VA2-4X/200JV

R901301829 ZDB6VA2-4X/200P140

R900409886 ZDB6VA2-4X/200V

R900942526 ZDB6VA2-4X/200V=LB

R901052140 ZDB6VA2-4X/200V=TE

R900431071 ZDB6VA2-4X/315

R900716232 ZDB6VA2-4X/315MIL15

R901043790 ZDB6VA2-4X/315-185

R901020255 ZDB6VA2-4X/315-205

R901395248 ZDB6VA2-4X/315-210V

R901132023 ZDB6VA2-4X/315-220V

R900786684 ZDB6VA2-4X/315-225

R901139993 ZDB6VA2-4X/315-250V

R901199342 ZDB6VA2-4X/315-280V

R900518075 ZDB6VA2-4X/315JV

R900409893 ZDB6VA2-4X/315V

R900593318 ZDB6VA2-4X/350SO2

R900508780 ZDB6VA2-4X/350V

R900431678 ZDB6VA2-4X/50

R900934814 ZDB6VA2-4X/50-10V

R900934815 ZDB6VA2-4X/50-15V

R901336540 ZDB6VA2-4X/50P20V

R900902073 ZDB6VA2-4X/50P45V

R900406615 ZDB6VA2-4X/50V

R900428435 ZDB6VA3-4X/100

R900433335 ZDB6VA3-4X/100V

R900438967 ZDB6VA3-4X/200

R900403470 ZDB6VA3-4X/200V

R900460338 ZDB6VA3-4X/315

R900422828 ZDB6VA3-4X/315V

R900425683 ZDB6VA3-4X/50

R900598663 ZDB6VA3-4X/50V

R900538386 ZDB6VA7-4X/100V

R900528589 ZDB6VA7-4X/200V

R901015320 ZDB6VA7-4X/315V

R900527458 ZDB6VA7-4X/50V

R900472365 ZDB6VB.-4X/...V

R900967507 ZDB6VB1-4X/100

R900598152 ZDB6VB1-4X/100V

R901035634 ZDB6VB1-4X/100V/60

R900959754 ZDB6VB1-4X/200

R900518826 ZDB6VB1-4X/200V

R900909480 ZDB6VB1-4X/315

R900551788 ZDB6VB1-4X/315V

R900967506 ZDB6VB1-4X/50

R900580996 ZDB6VB1-4X/50V

R900431401 ZDB6VB2-4X/100

R900564277 ZDB6VB2-4X/100MIL15

R901349085 ZDB6VB2-4X/100-30

R901350653 ZDB6VB2-4X/100-40

R901351188 ZDB6VB2-4X/100-45

R901203499 ZDB6VB2-4X/100-55

R901093041 ZDB6VB2-4X/100-60

R901269811 ZDB6VB2-4X/100-75V

R901394944 ZDB6VB2-4X/100-80V

R900977674 ZDB6VB2-4X/100JV

R900409936 ZDB6VB2-4X/100V

R900429509 ZDB6VB2-4X/200

R900442786 ZDB6VB2-4X/200MIL15

R901028565 ZDB6VB2-4X/200-100V

R901043262 ZDB6VB2-4X/200-140

R901415338 ZDB6VB2-4X/200-140V

R900978250 ZDB6VB2-4X/200-150

R900965729 ZDB6VB2-4X/200-160V

R901404717 ZDB6VB2-4X/200-180V

R900409854 ZDB6VB2-4X/200V

R901347239 ZDB6VB2-4X/200V/60

R900422061 ZDB6VB2-4X/315

R901087335 ZDB6VB2-4X/315-315

R900551072 ZDB6VB2-4X/315J

R900702024 ZDB6VB2-4X/315JV

R901126943 ZDB6VB2-4X/315P210

R900409896 ZDB6VB2-4X/315V

R409023170 ZDB6VB2-4X/315V 240BAR

R900940177 ZDB6VB2-4X/350

R900430645 ZDB6VB2-4X/50

R900533101 ZDB6VB2-4X/50MIL15

R900756773 ZDB6VB2-4X/50-15V

R900580329 ZDB6VB2-4X/50JV

R900422214 ZDB6VB2-4X/50V

R900431167 ZDB6VB3-4X/100

R900433336 ZDB6VB3-4X/100V

R900465884 ZDB6VB3-4X/200

R900516958 ZDB6VB3-4X/200V

R900454880 ZDB6VB3-4X/315

R900564860 ZDB6VB3-4X/315V

R900438971 ZDB6VB3-4X/50

R900440160 ZDB6VB3-4X/50V

R900503765 ZDB6VB7-4X/100V

R900518152 ZDB6VB7-4X/200V

R900907940 ZDB6VB7-4X/315V

R900552086 ZDB6VB7-4X/50V

R900476959 ZDB6VP.-4X/...V

R900507970 ZDB6VP1-4X/100

R900586621 ZDB6VP1-4X/100V

R900447152 ZDB6VP1-4X/200

R900596138 ZDB6VP1-4X/200V

R901048422 ZDB6VP1-4X/200XCV

R900445935 ZDB6VP1-4X/315

R900598455 ZDB6VP1-4X/315V

R901143637 ZDB6VP1-4X/315XCV

R900507459 ZDB6VP1-4X/50

R900449008 ZDB6VP1-4X/50V

R900423274 ZDB6VP2-4X/100

R900955817 ZDB6VP2-4X/100MIL15

R901053006 ZDB6VP2-4X/100-15

R901019000 ZDB6VP2-4X/100-20

R901187406 ZDB6VP2-4X/100-25

R901023775 ZDB6VP2-4X/100-30

R901079889 ZDB6VP2-4X/100-65

R901171810 ZDB6VP2-4X/100-70

R901415339 ZDB6VP2-4X/100-70V

R900559699 ZDB6VP2-4X/100-80V

R901019003 ZDB6VP2-4X/100-90

R901308662 ZDB6VP2-4X/100-95V

R901227829 ZDB6VP2-4X/100J

R900596557 ZDB6VP2-4X/100JV

R900931546 ZDB6VP2-4X/100P100V

R901278441 ZDB6VP2-4X/100P80V

R901294372 ZDB6VP2-4X/100P85V

R900409933 ZDB6VP2-4X/100V

R900747682 ZDB6VP2-4X/100V/60

R901136404 ZDB6VP2-4X/160V

R901136849 ZDB6VP2-4X/160V/60

R900428339 ZDB6VP2-4X/200

R900442785 ZDB6VP2-4X/200MIL15

R900787893 ZDB6VP2-4X/200-100

R901111226 ZDB6VP2-4X/200-130V

R901062625 ZDB6VP2-4X/200-140

R901415340 ZDB6VP2-4X/200-140V

R900961530 ZDB6VP2-4X/200-160V

R900578300 ZDB6VP2-4X/200-175V

R901241710 ZDB6VP2-4X/200-180

R901415341 ZDB6VP2-4X/200-180V

R901072623 ZDB6VP2-4X/200-200

R901269812 ZDB6VP2-4X/200-200V

R900922677 ZDB6VP2-4X/200=LB

R900439340 ZDB6VP2-4X/200JV

R901415343 ZDB6VP2-4X/200P105V

R900972357 ZDB6VP2-4X/200P200

R900409844 ZDB6VP2-4X/200V

R900449982 ZDB6VP2-4X/200VSO2

R900422075 ZDB6VP2-4X/315

R900512598 ZDB6VP2-4X/315MIL15

R900583753 ZDB6VP2-4X/315SO280

R900595528 ZDB6VP2-4X/315SO700

R900786649 ZDB6VP2-4X/315-200

R901020254 ZDB6VP2-4X/315-205

R901330466 ZDB6VP2-4X/315-210

R900721392 ZDB6VP2-4X/315-230

R901240731 ZDB6VP2-4X/315-80V

R901397224 ZDB6VP2-4X/315/60

R900434630 ZDB6VP2-4X/315J

R900437273 ZDB6VP2-4X/315JV

R900524252 ZDB6VP2-4X/315MK

R900760681 ZDB6VP2-4X/315P230

R901212843 ZDB6VP2-4X/315P250

R901407660 ZDB6VP2-4X/315P265V

R901224722 ZDB6VP2-4X/315P310V

R900409898 ZDB6VP2-4X/315V

R901424406 ZDB6VP2-4X/315VSO55

R901101916 ZDB6VP2-4X/315V/60

R901052212 ZDB6VP2-4X/315V=TE

R900561458 ZDB6VP2-4X/350V

R900432804 ZDB6VP2-4X/50

產品報價及貨期說明 因工業液壓、自動化各品牌備件型號繁多，歐美產品價格貨期實時變化，因此很難實時標出準確價格，故具體產品信息、報價及貨期請以我公司報價單為準 ,給您帶來不便敬請諒解！以上信息由武漢百士公布，解釋權歸武漢百士自動化設備有限公司所有。感謝您的合作，竭誠為您服務。