立式浮球式疏水閥

一、進口立式浮球式疏水閥產品概述

品牌：英格蘭姆INGRAM

進口立式自由浮球式蒸汽疏水閥，Vertical free ball float type steam trap，也叫立式疏水閥，立式疏水器，專項使用于立式的安裝形式，根據浮力的原理，使閥體內的浮球隨水位變化作升降運動，以達到閥門啟閉，即排水阻汽的作用的疏水閥。

裝置剛起動時，管道內出現空氣和低溫冷凝水，雙金屬自動排空氣元件把浮球推離閥座，閥門打開，排除不凝結氣體，低溫冷凝水流進疏水閥，浮球上升，凝結水迅速排放。裝置很快提升溫度，管道內溫度上升到飽和溫度之前，雙金屬自動排空氣元件感溫變型伸直；蒸汽疏水閥進入正常運行狀況，浮球隨液位升降調節閥孔流量；當凝結水停止進入時，浮球隨介質流向逼近閥座，關閉閥門。立式自由浮球式蒸汽疏水閥的閥座總處于液位以下，形成水封，無蒸汽泄漏。

英格蘭姆INGRAM立式自由浮球式蒸汽疏水閥適用于蒸汽主管和伴熱管線，蒸汽管網及凝結水回收系統，特別對加熱速度要求快，溫度控制要求嚴，加熱設備不能積存凝結水的工藝更為合適，廣泛用于石油、化工、紡織、制藥等工礦企業。

First, imported vertical floating ball trap Product Overview

Brand:  INGRAM

Imported vertical free float type steam trap, Vertical free ball float type steam trap, also called vertical vertical drain valve, steam trap, dedicated to the vertical installation form, according to the principle of buoyancy, the floating ball valve body with the water level change of lifting movement, to achieve open and close the valve, drain valve drainage the effect of steam resistance.

 

The device just starting when the temperature of air and condensate water occur in the pipes, bimetal automatic air exhaust components of the floating ball is pushed away from the valve seat, the valve open, remove non condensable gas, low temperature water into the condensate trap, float up, condensation water to a rapid discharge. The device quickly raise the temperature before the pipe temperature rises to saturation double metal temperature, automatic air exhausting element temperature variant straight; steam traps in normal operation condition, float down with the liquid flow cool valve hole; when the condensed water to stop, the float with the medium flow approaching seat, close the valve. The vertical free floating ball type steam valve seat total in the level below to form a water seal, No steam leakage

 

Englands INGRAM vertical free floating ball type steam trap charge applies to steam and heating pipes, steam pipe and water recycling system, especially for the requirements of fast heating speed, temperature cool requirements, process heating equipment can not accumulate the condensed water is more suitable, are widely used in petroleum, chemical, textile, pharmaceutical and other industrial and mining enterprise.

 

二、進口立式浮球式疏水閥產品特點：

1、立式浮球式疏水閥不受壓力、溫度、冷凝水流量波動的影響，連續排水，有水即排，性能穩定，較小過冷度為 0℃ ，能使加熱設備達到較佳工作效率。

2、立式浮球式疏水閥能排連續飽和水，至使設備凝結水滯存量較少、升溫快、加熱溫度穩定。

3、立式浮球式疏水閥有自動排冷空氣裝置，無汽鎖現象，工作平衡無噪音。

4、內部有一個精細研磨的不銹鋼空心浮球，既是浮子又是啟閉件，無易損零件，使用壽命很長。

Two, imported vertical floating ball trap product features:

 

1, vertical floating ball trap is not affected by pressure, temperature, condensate flow fluctuations, continuous drainage, water discharge, stable performance, the minimum undercooling is 0 degrees, can make the heating equipment to achieve the best efficiency

 

2, vertical float type drain valve can row continuous saturated water, to the equipment condensate less storage, heating faster, heating temperature is stable

 

3, vertical floating ball trap has automatic exhaust air device, no steam lock phenomenon, work balance, no noise

 

4, there is a fine grinding of stainless steel hollow floating ball, which is not only float, but also open and close parts, no wearing parts, long service life

 

三、進口立式浮球式疏水閥尺寸圖

 

公稱通徑	L（mm）	L1（mm）	H（mm）	H1（mm）
15	160	62.5	112.5	30
20	160	62.5	112.5	30
25	160	62.5	112.5	30
32	250	100	172	38
40	250	100	172	38
50	250	100	172	38