ZDB10VA1-40200溢流閥

ZDB10VA1-40/200溢流閥

武漢百士自動化設備有限公司專注于液壓、氣動、工控自動化備件銷售，熱誠歡迎新老客戶咨詢購買！

溢流閥在使用中有時會出現調壓失靈現象。先導式溢流閥調壓失靈現象有二種情況：一種是調節調壓手輪建立不起壓力，或壓力達不到額定數值；另一種調節手輪壓力不下降，甚至不斷升壓。出現調壓失靈，除閥芯因種種原因造成徑向卡緊外，還有下列一些原因：

一是主閥體（2）阻尼器堵塞，油壓傳遞不到主閥上腔和導閥前腔，導閥就失去對主閥壓力的調節作用。因主閥上腔無油壓力，彈簧力又很小，所以主閥變成了一個彈簧力很小的直動型溢流閥，在進油腔壓力很低的情況下，主閥就打開溢流，系統就建立不起壓力。

壓力達不到額定值的原因，是調壓彈簧變形或選用錯誤，調壓彈簧壓縮行程不夠，閥的內泄漏過大，或?qū)чy部分錐閥過度磨損等。

第二是阻尼器（3）堵塞，油壓傳遞不到錐閥上，導閥就失去了支主閥壓力的調節作用。阻尼器（小孔）堵塞后，在任何壓力下錐閥都不會打開溢流油液，閥內始終無油液流動，主閥上下腔壓力一直相等，由于主閥芯上端環形承壓面積大于下端環形承壓面積，所以主閥也始終關閉，不會溢流，主閥壓力隨負載增加而上升。當執行機構停止工作時，系統壓力就會無限升高。除這些原因以外，尚需檢查外控口是否堵住，錐閥安裝是否良好等。

其它故障

溢流閥在裝配或使用中，由于O形密封圈、組合密封圈的損壞，或者安裝螺釘、管接頭的松動，都可能造成不應有的外泄漏。

如果錐閥或主閥芯磨損過大，或者密封面接觸不良，還將造成內泄漏過大，甚至影響正常工作。

電磁溢流閥常見的故障有先導電磁閥工作失靈、主閥調壓失靈和卸荷時的沖擊噪聲等。后者可通過調節加置的緩沖器來減少或清理。如不帶緩沖器，則可在主閥溢流口加一背壓閥。（壓力一般調至5kgf/cm2左右，即0.5MPa）。[1] 

R900484774 DBDS6P1X/315SO74

R901312605 DBDS6P1X/315-140

R901394238 DBDS6P1X/315-140JP002

R901060660 DBDS6P1X/315-210

R901411310 DBDS6P1X/315-225

R900920300 DBDS6P1X/315-230

R900906210 DBDS6P1X/315-240

R900574961 DBDS6P1X/315-250

R901312606 DBDS6P1X/315-270

R901394239 DBDS6P1X/315-270JP002

R900574960 DBDS6P1X/315-290

R900900923 DBDS6P1X/315-315

R901394237 DBDS6P1X/315-45JP002

R900394464 DBDS6P1X/315/12

R900476937 DBDS6P1X/315/5

R900407507 DBDS6P1X/315/V/5

R900415150 DBDS6P1X/315B

R900773191 DBDS6P1X/315E

R900486142 DBDS6P1X/315J

R900933682 DBDS6P1X/315P240

R900435450 DBDS6P1X/315V

R900585432 DBDS6P1X/315VB

R900572961 DBDS6P1X/330B

R901244638 DBDS6P1X/330E

R900572962 DBDS6P1X/340B

R900779532 DBDS6P1X/350E

R900423731 DBDS6P1X/400

R987282225 DBDS6P1X/400-330

R901390428 DBDS6P1X/400-340

R901263844 DBDS6P1X/400-350

R901109298 DBDS6P1X/400-380

R900924604 DBDS6P1X/400/12

R900471602 DBDS6P1X/400/5

R900414261 DBDS6P1X/400/V/5

R900424300 DBDS6P1X/400B

R900777834 DBDS6P1X/400E

R900389464 DBDS6P1X/400J

R900459771 DBDS6P1X/400V

R900537817 DBDS6P1X/400V/12

R901046431 DBDS6P1X/40E

R900423732 DBDS6P1X/50

R900488026 DBDS6P1X/50SO130

R900334975 DBDS6P1X/50SO57

R900487131 DBDS6P1X/50SO60

R900470071 DBDS6P1X/50SO62

R900460389 DBDS6P1X/50W1

R900962502 DBDS6P1X/50W100

R900474570 DBDS6P1X/50/5

R900370287 DBDS6P1X/50/B

R900431434 DBDS6P1X/50/V/5

R900963992 DBDS6P1X/50B

R901129991 DBDS6P1X/50E

R900486143 DBDS6P1X/50J

R900923300 DBDS6P1X/50P40

R900438610 DBDS6P1X/50V

R983048396 DBDS6P1X/50VIN010

R900712021 DBDS6P1X/50V/12

R901180768 DBDS6P1X/50VE

R901339625 DBDS6P1X/55E

R900427247 DBDS6P1X/60B

R900429256 DBDS6P1X/60B

R900572417 DBDS6P1X/70B

R900572419 DBDS6P1X/75B

R900572420 DBDS6P1X/80B

R901016661 DBDS6P1X/80VE

R901425885 DBDS6P1X/85E

R901339627 DBDS6P1X/90E

R900423733 DBDS8G1X/100

R900472405 DBDS8G1X/100W1

R900519095 DBDS8G1X/100/12

R900584213 DBDS8G1X/100/5

R900955086 DBDS8G1X/100B

R900586222 DBDS8G1X/100J

R900437054 DBDS8G1X/100V

R900333975 DBDS8G1X/110/5B

R900457172 DBDS8G1X/110B

R900505514 DBDS8G1X/170B

R901045916 DBDS8G1X/170E

R901037981 DBDS8G1X/180E

R900423734 DBDS8G1X/200

R900371736 DBDS8G1X/200W1

R901012181 DBDS8G1X/200-150

R900504669 DBDS8G1X/200/12

R900572597 DBDS8G1X/200B

R900561633 DBDS8G1X/200JV

R900328446 DBDS8G1X/200V

R900421088 DBDS8G1X/210B

R900427885 DBDS8G1X/25

R900523658 DBDS8G1X/25SO128

R900389277 DBDS8G1X/25SO150

R900546553 DBDS8G1X/25SO700

R900464795 DBDS8G1X/25W1

R900581024 DBDS8G1X/25/12

R900436630 DBDS8G1X/25J

R900475974 DBDS8G1X/25V

R900925911 DBDS8G1X/270B

R900572682 DBDS8G1X/280B

R900572683 DBDS8G1X/300B

R900423735 DBDS8G1X/315

R900409674 DBDS8G1X/315SO450

R900578290 DBDS8G1X/315SO700

R900372708 DBDS8G1X/315W1

R900900335 DBDS8G1X/315-240

R900431917 DBDS8G1X/315B

R901008047 DBDS8G1X/315E

R901344121 DBDS8G1X/315V

R900390330 DBDS8G1X/315VB

R900726491 DBDS8G1X/345B

R901003377 DBDS8G1X/345E

R900572963 DBDS8G1X/350B

R900427603 DBDS8G1X/400

R900518713 DBDS8G1X/400/12

R900388795 DBDS8G1X/400/2

R900441003 DBDS8G1X/400B

R900459874 DBDS8G1X/400V

R900423736 DBDS8G1X/50

R900477938 DBDS8G1X/50SO50

R900339250 DBDS8G1X/50W1

R900339250 DBDS8G1X/50W1

R900360009 DBDS8G1X/50W4

R900539047 DBDS8G1X/50/12